[1]王迪,王定标,杨雨燊,等.跨临界CO2热泵系统最优排气压力模拟与实验研究[J].郑州大学学报(工学版),2021,42(4):33-39.[doi:10.13705/j.issn.1671-6833.2021.04.001]
　Wang Di,Wang Dingbiao,Yang Yuxi,et al.Simulation and Experimental Analysis on the Optimal Discharge Pressure of a Transcritical CO 2 Heat Pump System[J].Journal of Zhengzhou University (Engineering Science),2021,42(4):33-39.[doi:10.13705/j.issn.1671-6833.2021.04.001]
点击复制

跨临界CO2热泵系统最优排气压力模拟与实验研究()
分享到：

《郑州大学学报(工学版)》[ISSN:1671-6833/CN:41-1339/T]

卷:
42
期数:
2021年4期
页码:
33-39
栏目:
出版日期:
2021-07-30

文章信息/Info

Title:
Simulation and Experimental Analysis on the Optimal Discharge Pressure of a Transcritical CO 2 Heat Pump System
作者:
王迪1,2,王定标1,2,杨雨燊1,2,刘鑫鑫1,2,向飒2
1.郑州大学 机械与动力工程学院，河南 郑州 450001；2.郑州大学 热能系统节能技术与装备教育部工程研究中心，河南 郑州 450001
Author(s):
Wang Di1,2; Wang Dingbiao1,2; Yang Yuxi1,2; Liu Xinxin1,2; Xiang Yan2;
1.School of Mechanical and Power Engineering,  Zhengzhou University, Zhengzhou 450001, China; 2.Engineering Research Center of Energy Saving Technology and Equipments in Thermal System of Ministry of Education, Zhengzhou University Zhengzhou 450001, China
关键词:
Keywords:
intermediate heat exchanger; across the critical CO2; MATLAB; optimal exhaust pressure; correlations
DOI:
10.13705/j.issn.1671-6833.2021.04.001
文献标志码:
A
摘要:

为探究各操作变量对系统最优排气压力的影响，基于 MATLAB 平台建立了系统仿真模型，分析了特定工况下，在有、无中间换热器的情况下，系统各变量对系统 COP （制热性能系数）的影响，确定了影响系统最优排气压力的主要因素，并拟合了相应的关联式。同时利用跨临界 CO2 热泵系统实验台，在不同蒸发温度与气冷器出口温度条件下研究了排气压力对系统性能的影响，得到不同工况对应的最优排气压力值，并与最优排气压力仿真值进行对比验证。结果表明：系统存在最优排气压力，使得系统 COP 在此压力下达到最大值；加入中间换热器以后，系统 COP 有所增加，但最优排气压力几乎不变；高的干度、过热度对系统 COP 的影响很小，系统 COP 随着气冷器出口温度的升高急剧下降，随蒸发温度的升高而增大，最优排气压力主要与气冷器出口温度和蒸发温度有关；实验得到的系统最优排气压力值与仿真值的最大相对误差为 3 ％，仿真拟合的最优排气压力关联式与实际运行过程匹配良好。


Abstract:
To explore the impact of operating variables on the system optimal exhaust pressure,the influence of the system simulation model was built based on the MATLAB platform.It analyzed the specific conditions,in the presence of the heat exchanger in the middle of the case,the system would effect COP of the system,the variables to determine the main factors affecting the optimal exhaust pressure system,and fitting the corresponding correlations.At the same time,the influence of exhaust pressure on the system performance was studied under different evaporation temperature and air cooler outlet temperature by using the cross-critical CO2 heat pump system test platform.And the corresponding optimal exhaust pressure value under different working conditions was obtained,which was verified by comparison with the simulation value of optimal exhaust pressure.The results show that there was an optimal exhaust pressure in the system,and COP of the system could reaches the maximum under this pressure.With the addition of intermediate heat exchanger,COP of the system increased somewhat,but the optimal exhaust pressure was almost unchanged.High dryness and superheat had little effect on COP of the system.COP of the system decreased sharply with the increase of the outlet temperature of the air cooler,and increased with the increase of the evaporation temperature.The optimal exhaust pressure was mainly related to the outlet temperature of the air cooler and the evaporation temperature.The maximum error between the optimal exhaust pressure obtained by experiment and that obtained by simulation was 3%,the correlation formula of optimal exhaust pressure fitted by simulation was well matched with the actual operation process.

参考文献/References:

[1] 孙西峰,韩杨.汽车空调替代制冷剂的比较[J].制冷与空调,2015,15(5):60-67.

[2] LORENTZEN G,PETTERSEN J.A new,efficient and environmentally benign system for car air-conditioning[J].International journal of refrigeration,1993,16(1):4-12.
[3] LIAO S M,ZHAO T S,JAKOBSEN A.A correlation of optimal heat rejection pressures in transcritical carbon dioxide cycles[J].Applied thermal engineering,2000,20(9):831-841.
[4] SARKAR J,BHATTACHARYYA S,GOPAL M R.Optimization of a transcritical CO2 heat pump cycle for simultaneous cooling and heating applications[J].International journal of refrigeration,2004,27(8):830-838.
[5] CHEN Y,GU J J.The optimum high pressure for CO2 transcritical refrigeration systems with internal heat exchangers[J].International journal of refrigeration,2005,28(8):1238-1249.
[6] ZHANG F Z,JIANG P X,LIN Y S,et al.Efficiencies of subcritical and transcritical CO2 inverse cycles with and without an internal heat exchanger[J].Applied thermal engineering,2011,31(4):432-438.
[7] 宋昱龙,唐学平,王守国,等.空气源跨临界CO2热泵最优排气压力的理论和实验[J].西安交通大学学报,2014,48(9):81-87.
[8] 胡余生,刘雪涛,李敏霞,等.CO2跨临界热泵系统特性再分析[J].化工进展,2020,39(4):1252-1258.
[9] 方健珉,王静,孙西峰,等.回热器对电动汽车跨临界CO2制冷系统影响的实验研究[J].西安交通大学学报,2020,54(6):155-160.
[10] 胡斌,李耀宇,曹锋,等.跨临界CO2热泵系统最优排气压力的极值搜索控制[J].制冷学报,2016,37(3):81-87.
[11] 刘迎福.CO2跨临界制冷循环的实验研究与性能优化[D].北京:华北电力大学,2011.
[12] 叶祖樑,王驿凯,潘祖栋,等.空气源跨临界CO2热泵中回热器影响的研究[J].西安交通大学学报,2019,53(5):1-8.
[13] CAO F,CUI C,WEI X Y,et al.The experimental investigation on a novel transcritical CO2 heat pump combined system for space heating[J].International journal of refrigeration,2019,106:539-548.

更新日期/Last Update: 2021-08-26